EC5SAW-24S05N Cincon

V10 EC5SAW SERIES 10 WATT WIDE INPUT DC-DC CONVERTERS FEATURE * 4:1 Input Range * Regulated Outputs * 3000VDC/2000VAC Isolation * Efficiency Up to 89.5% * Compact SIP8 Package * Remote On/Off Control * 6.6-10W Isolated Output * Fixed Switching Frequency * No Tantalum Capacitor Inside * Input Under-Voltage Protection * Low No Load Power Consumption * Continuous Short Circuit Protection MODEL INPUT OUTPUT OUTPUT CURRENT INPUT CURRENT %EFF. CAPACITOR NUMBER VOLTAGE(4) VOLTAGE LOAD MAX. MIN. MAX. NO LOAD FULL LOAD (3) (2) EC5SAW-24S33N 9-36 VDC 3.3 VDC 0 mA 2000 mA 6 mA 336 mA 81 81.5 2000uF EC5SAW-24S05N 9-36 VDC 5 VDC 0 mA 2000 mA 6 mA 490 mA 83.5 85 2000uF EC5SAW-24S12N 9-36 VDC 12 VDC 0 mA 833 mA 6 mA 473 mA 87 89 833uF EC5SAW-24S15N 9-36 VDC 15 VDC 0 mA 666 mA 6 mA 468 mA 88.5 89.5 666uF EC5SAW-24D05N 9-36 VDC 5 VDC 0 mA 1000 mA 6 mA 490 mA 84 85 1000uF EC5SAW-24D12N 9-36 VDC 12 VDC 0 mA 417 mA 7 mA 468 mA 88.5 89 417uF EC5SAW-24D15N 9-36 VDC 15 VDC 0 mA 333 mA 7 mA 468 mA 88.5 89 333uF EC5SAW-48S33N 18-75 VDC 3.3 VDC 0 mA 2000 mA 6 mA 168 mA 81 81 2000uF EC5SAW-48S05N 18-75 VDC 5 VDC 0 mA 2000 mA 6 mA 245 mA 84 85 2000uF EC5SAW-48S12N 18-75 VDC 12 VDC 0 mA 833 mA 6 mA 237 mA 87.5 88 833uF EC5SAW-48S15N 18-75 VDC 15 VDC 0 mA 666 mA 6 mA 234 mA 87.5 88 666uF EC5SAW-48D05N 18-75 VDC 5 VDC 0 mA 1000 mA 6 mA 245 mA 84 85 1000uF EC5SAW-48D12N 18-75 VDC 12 VDC 0 mA 417 mA 6 mA 234 mA 88 88 417uF EC5SAW-48D15N 18-75 VDC 15 VDC 0 mA 333 mA 6 mA 234 mA 87.5 88 333uF NOTE: 1. Nominal Input Voltage 24 or 48 VDC 2. Measured at Nominal Input Voltage 3. Measured at 12VDC for 24Vin, 24VDC for 48Vin 4. For 3.3Vo, 5Vo & 5Vo has Derating by Input is Required Show Fig.1 1 V10 SPECIFICATIONS All Specifications Typical At Nominal Line, Full Load, and 25 Unless Otherwise Noted INPUT SPECIFICATIONS: GENERAL SPECIFICATIONS: Input Voltage Range ............................. 24V ..................... 9-36V Efficiency ...................................................................... See Table 48V.................... 18-75V Isolation Voltage ............ Input/Output ........ 3000VDC min. Input Surge Voltage (100 ms max.) ..... 24V 50VDC max. Input/Output ....................... 2000VAC min. 9 48V. 100VDC max. Isolation Resistance ................................................. 10 ohm min. Input Filter ........ Capacitive Isolation Capacitance ... 50pF max. Remote On/Off Control: Switching Frequency ................................................. 530KHz typ. Operating Ambient Temperature ... -40 to +85 Module On Open or High Impedance Module Off 2mA to 4mA De-rating, Above 50 ... Linearly to Zero power at 105 Module Off (Input Idle Current) .... 2.5mA max. Case Temperature (note4) .. 105 max. Cooling ... Natural Convection OUTPUT SPECIFICATIONS: Voltage Accuracy ............................................................. 1.0% max. Storage Temperature ..................... -55 to +125 Humidity .. 95% RH max. Non condensing Voltage Balance (Dual) .... 1.0% max Transient Response: 75%~100% Step Load Change MTBF . MIL-HDBK-217F, GB, 25 , Full Load .. 1930Khrs typ. Dimensions ................ 0.87x0.37x0.47 inches (22.0x9.5x12.0mm) Error Band 5% Vout Nominal, Recovery Time ... < 250s Ripple & Noise, 20MHz BW (Note 5) .... 3.3V & 5V & 5V 100mV pk-pk max. Case Material Non-Conductive Black Plastic 12V/15V/12V/15V..... 1%Vo max. Weight .... 4.9g Temperature Coefficient .......................................... 0.02%/C max. NOTE: Short Circuit Protection ........................................................... Continuous 1. Measured from high line to low line. Line Regulation (note1) ............................ 0.2% max. 2. Measured from full load to no load. 3. For asymmetric loading, both channels must be at 25% load or more. Load Regulation (note2) ..................................... 1.0% max. Cross Regulation (Dual note3) Asymmetrical Load 25%/100% .. 5.0% max. 4. Maximum case temperature under any operating condition should Current Limit ...180% typ. not be exceeded 105. Start up time ....................... 5ms typ. 5. Output ripple and noise measured with 1uF ceramic capacitor CASE SA DIMENSIONS: All Dimensions In Inches (mm) TolerancesInches Millimeters X.XX=0.02 X. X=0.5 Pin 0.002 0.05 0.87 (22.0) PIN CONNECTION Pin Single Dual Fig1. Input Voltage Derating Curve 1 -V Input -V Input 2 +V Input +V Input 3 On/Off On/Off 0.10 (2.5) 6 +V Output +V Output 0.70 (17.8) 7 -V Output Common Bottom View 8 NC -V Output Derating Curve : 1 2 3 6 7 8 Load (%) 100 0.08 (2.1) 0.02 (0.5) -3.45%/ C 50 Fig2. Typical Derating Curve for Naturel Convection (Deg. C) -40 71 100 a. Operating Temperature : -40C to 71C ---> without derating b. Operating Temperature : 71 C to 100C ---> derating (-3.45%/ C) 2 0.01 (0.3) 0.16 (4.1) 0.02 (0.5) 0.14 (3.5) 0.47 (12.0) 0.37 (9.5)