EC6E04 Cincon

V10 EC6E SERIES 20 - 30WATT 4:1 INPUT RANGE DC-DC CONVERTERS FEATURES * 30W Isolated Output * 4:1 Input Range * Six-Sided Shield Metal Case * Remote ON/OFF Control * Efficiency to 84% * Fixed 200KHz Switching Frequency * Regulated Outputs INPUT CURRENT MODEL INPUT OUTPUT OUTPUT % SIZE NUMBER VOLTAGE VOLTAGE CURRENT EFF. NO LOAD FULL LOAD EC6E01 9-36 VDC 5 VDC 5000 mA 20 mA 1350 mA 77 2.56x3 EC6E02 9-36 VDC 12 VDC 2500 mA 20 mA 1560 mA 80 2.56x3 EC6E03 9-36 VDC 15 VDC 2000 mA 20 mA 1560 mA 80 2.56x3 EC6E04 9-36 VDC 12 VDC 1250 mA 25 mA 1560 mA 80 2.56x3 EC6E05 9-36 VDC 15 VDC 1000 mA 25 mA 1560 mA 80 2.56x3 EC6E06 9-36 VDC 5/12 VDC 3000/625 mA 25 mA 1650 mA 76 2.56x3 EC6E07 9-36 VDC 5/15 VDC 3000/500 mA 25 mA 1650 mA 76 2.56x3 EC6E08 9-36 VDC +5/+12/-5 VDC 3000/600/1000 mA 25 mA 1450 mA 78 2.56x3 EC6E11 18-72 VDC 5 VDC 5000 mA 15 mA 670 mA 78 2.56x3 EC6E12 18-72 VDC 12 VDC 2500 mA 15 mA 770 mA 81 2.56x3 EC6E13 18-72 VDC 15 VDC 2000 mA 15 mA 770 mA 81 2.56x3 EC6E14 18-72 VDC 12 VDC 1250 mA 20 mA 750 mA 84 2.56x3 EC6E15 18-72 VDC 15 VDC 1000 mA 20 mA 750 mA 84 2.56x3 EC6E16 18-72 VDC 5/12 VDC 3000/625 mA 20 mA 790 mA 79 2.56x3 EC6E17 18-72 VDC 5/15 VDC 3000/500 mA 20 mA 790 mA 80 2.56x3 EC6E18 18-72 VDC +5/+12/-5 VDC 3000/600/1000 mA 20 mA 725 mA 78 2.56x3 NOTE: 1. Nominal Input Voltage 24 or 48VDC 1 V10 SPECIFICATIONS All Specifications Typical At Nominal Line, Full Load, and 25 Unless Otherwise Noted INPUT SPECIFICATIONS: GENERAL SPECIFICATIONS: Input Voltage Range .............. 24V ......................... 9 36V Efficiency ................................................................................... See Table 48V .. 18 72V Isolation Voltage .............................................................. 500 VDC min. 9 Input Filter ........ Pi Type Isolation Resistance ................................................ 10 ohms Switching Frequency .............................................................. 200KHz typ. OUTPUT SPECIFICATIONS: Voltage Accuracy Operating Ambient Temperature Range ..................... 25 to +71 Single Output .... 1.0% max. De-rating, Above 71 ... Linearly to Zero power at 100 Dual +Output .... 1.0% max. Case Temperature (note 3) .......... 100 max. Dual Output ... 3.0% max. Cooling .... Natural Convection Triple 5V ... 1.0% max. Storage Temperature Range .......... 55 to +105 12V/15V ... 5.0% max . EMI/RFI .. Six-Sided Continuous Shield - 5 V . 2 . 0 % ma x . Dimensions . 2.563.000.83 inches (65.076.221.1mm) Voltage Balance (Dual) 1.0% max. Case Material . Black Coated Copper With Non-Conductive Base Transient Response Weight ..... 175g Single 25% Step Load Change . <500us NOTE: Dual FL-1/2L1% Error Band .... <500us 1. Measured from high line to low line External Trim Adj. Range 10% 2. Measured from full load to 1/4 full load Ripple and Noise, 20MHz BW .. 10mV RMS max. 3. Maximum case temperature under any operating condition should 75mV p-p max. not be exceeded 100 . Temperature Coefficient .. 0.02%/ TRIPLE OUTPUT LOADING TABLE (1) Short Circuit Protection .... Continuous Amperes Output Line Regulation Single/Dual (note 1) ........... 0.2% max. Voltage T r i p l e 1 . 0 % m a x . (Pin No.) Min. (2) Nom. Load Regulation Single/Dual (note 2) .............. 1.0% max. 6 +5 0.25 3.0 T r i p l e 5 . 0 % m a x . 3 & 5 +12 & -12 0.10 0.625 Typical Derating curve for Natural Convection +15 & -15 0.10 0.500 3 & 5 120% -25 71 +12 & -5 0.10/0.10 0.60/1.0 3 & 5 100% 80% NOTE: 60% 1. Maximum total power from all outputs is limited to 30 watts Natural 40% but no output should be allowed to exceed its maximum current Convection 20% 2. Minimum current on each output is required to maintain specified regulation 100 0% Remote On/Off Control -25 0 25 50 75 100 o Ambient Temperature( C) Logic Compatibility CMOS or Open Collector TTL Case E Dimensions: Ec-On >+5.5 VDC or Open Circuit Ec-Off <1.8 VDC All Dimensions In Inches(mm) Tolerances Inches: X.XX= 0.04 , X.XXX= 0.010 Millimeters: X.X= 1.0 , X.XX=0.25 Shutdown ldle Current 10mA Control Common Referenced to Input Minus EXTERNAL OUTPUT TRIM Output may optionally be externally trimmed (10%) with a fixed resistor or an external trimpot as shown PIN CONNECTION Pin Single Output Dual Output Triple Output PIN5 PIN5 +Input +Input +Input 1. TRIM 2. -Input -Input -Input UP +Sense 3. +Output +Output 10K ohms PIN4 4. Output Trim Common Common PIN4 TRIMPOT -Output -Output 5. -Sense PIN4 6. +Output No Pin +5V Output TRIM 7. -Output No Pin No Pin DOWN min Remote On/Off Control 8. PIN3 PIN3 2 LOAD(%) DIA