800W Parallel (N+1) With PFC Function SCP-800 s e ri e s Features : AC input 180~260VAC only PF> 0.98 230VAC Protections: Short circuit / Overload / Over voltage / Over temperature Built in remote sense function Built-in remote ON-OFF control Built-in power good signal output Built-in parallel operation function(N+1) Can adjust from 20~100% output voltage by external control 1-5V Forced air cooling by built-in DC fan 3 years warranty SPECIFICATION ORDER NO. SCP-800-09 SCP-800-12 SCP-800-15 SCP-800-18 SCP-800-24 SCP-800-36 SCP-800-48 SCP-800-60 SAFETY MODEL NO. 800S-P009 800S-P012 800S-P015 800S-P018 800S-P024 800S-P036 800S-P048 800S-P060 DC VOLTAGE 9V 12V 15V 18V 24V 36V 48V 60V RATED CURRENT 88A 66A 53A 44.4A 33A 22.2A 16A 13A CURRENT RANGE 0 ~ 88A 0 ~ 66A 0 ~ 53A 0 ~ 44.4A 0 ~ 33A 0 ~ 22.2A 0 ~ 16A 0 ~ 13A RATED POWER 792W 792W 795W 799W 792W 799W 768W 780W OUTPUT RIPPLE & NOISE (max.) Note.2 90mVp-p 120mVp-p 150mVp-p 180mVp-p 240mVp-p 360mVp-p 480mVp-p 500mVp-p VOLTAGE ADJ. RANGE 3.0% Typical adjustment by potentiometer 20% ~ 100% adjustment by 1 ~ 5VDC external control VOLTAGE TOLERANCE Note.3 1.5% 1.0% 1.0% 1.0% 1.0% 1.0% 1.0% 1.0% LINE REGULATION 0.5% 0.5% 0.5% 0.5% 0.5% 0.5% 0.5% 0.5% LOAD REGULATION 1.0% 0.5% 0.5% 0.5% 0.5% 0.5% 0.5% 0.5% SETUP, RISE, HOLD UP TIME 800ms, 400ms, 12ms at full load VOLTAGE RANGE 180 ~ 260VAC 260 ~ 370VDC see the derating curve FREQUENCY RANGE 47 ~ 63Hz POWER FACTOR >0.98 / 230VAC EFFICIENCY (Typ.) 83% 84% 85% 86% 88% 88% 89% 90% INPUT AC CURRENT 5.0A / 230VAC INRUSH CURRENT (max.) 60A / 230VAC LEAKAGE CURRENT(max.) 3.5mA / 240VAC 105~115% rated output power OVERLOAD Note.4 Protection type : Current limiting, delay shut down o/p voltage, re-power on to recover 110 ~ 135% Follow to output set up point PROTECTION OVER VOLTAGE Protection type : Shut down o/p voltage, re-power on to recover >100 / measure by heat sink, near transformer OVER TEMPERATURE Protection type : Shut down o/p voltage, recovers automatically after temperature goes down WORKING TEMP. -20 ~ +65 (Refer to output load derating curve) 20 ~ 90% RH non-condensing WORKING HUMIDITY STORAGE TEMP., HUMIDITY -20 ~ +85 10 ~ 95% RH ENVIRONMENT TEMP. COEFFICIENT 0.04% / (0 ~ 50 ) 10 ~ 200Hz, 2G 10min./1cycle, 60min. each along X, Y, Z axes VIBRATION SAFETY STANDARDS UL60950, TUV EN60950-1 approved WITHSTAND VOLTAGE I/P-O/P:3KVAC I/P-FG:1.5KVAC O/P-FG:0.5KVAC SAFETY & I/P-O/P, I/P-FG, OP/FG:100M Ohms / 500VDC / 25 / 70% RH ISOLATION RESISTANCE EMC EMI CONDUCTION & RADIATION Compliance to EN55022 (CISPR22) class A (Note. 5) HARMONIC CURRENT Compliance to EN61000-3-2,3 EMS IMMUNITY Compliance to EN61000-4-2,3,4,5,6,8,11, light industry level, criteria A Open collector of NPN transistor POWER GOOD SIGNAL SPECIAL FUNCTION DC Voltage Adj., remote sensing, remote control, parallel operation(refer to control terminal instruction manual) COOLING By fan, >20% load or >50 fan on OTHERS MTBF 74.9K hrs min. MIL-HDBK-217F(25 ) DIMENSION 290*120*68mm (L*W*H) PACKING 1.9kg 8pcs / 22kg / CARTON 1. All parameters NOT specially mentioned are measured at 230VAC input, rated load and 25 of ambient temperature. NOTE 2. Ripple & noise are measured at 20MHz of bandwidth by using a 12 twisted pair-wire terminated with a 0.1uf & 47uf parallel capacitor. 3. Tolerance : includes set up tolerance, line regulation and load regulation. 4. Current limiting 3 times(1.5s,3.0s,5.0s)Then intelligent auto recovery before shut down 5. The power supply is considered a component which will be installed into a final equipment. The final equipment must be re-confirmed that it still meets EMC directives. File Name: SCP-800-SPEC 2008-05-06800W Parallel (N+1) With PFC Function SCP-800 s e ri e s Mechanical Specification Unit:mm 18.5 41 10 190 10 39 30 9.2 11 CN1 6-32-4 1 2 3 4 5 6 7 8 1 2 3 M3(NUT)X3H-4 LED Vadj POS+ NEG- 120 251 30 9 M3(NUT) 3H-4 AIR FLOW BOTTOM SIDE M6 Terminal Pin No. Assignment Control terminal Pin No. Assignment (CN1) : Dinkle 51HDBC-O8P or equivalent Pin No. Assignment Pin No. Assignment Pin No. Assignment Mating With 1 AC/L 1 VS+ 5 PG 2 AC/N 2 VS- 6 PAR Dinkle 51SDB-O8P 3 FG VCI GND or equivalent 3 7 VCO INH 4 8 Derating Curve Ta=25 800 100 700 80 600 550 60 400 40 450 20 300 -20 -10 10 20 30 40 50 60 70 90 110 150 170 260 AMBIENT TEMPERATURE ( ) INPUT VOLTAGE (VAC) 60Hz File Name: SCP-800-SPEC 2008-05-06 LOAD (%) AC INPUT 15 38 OUTPUT POWER (W) DC OUTPUT NEG POS 26.5 68 17 89 14