Kleanium Circuit Board Cleaner Aerosol 1. CHEMICAL PRODUCT AND COMPANY IDENTIFICATION Product Name: Chemtools Kleanium Circuit Board Cleaner Aerosol Product Type: Flux solvent for industrial use. Part Numbers: CT-FRHD-300, -300AJ Company Address: Chemtools Pty., Ltd., PO Box 463, Emu Plains, NSW 2750 Ph: 1300 738 250 EMERGENCY PHONE: Australia: Poisons Information Centre 13 1126 International: Infotrac (708) 918 1900 2. COMPOSITION/INFORMATION ON INGREDIENTS Hazardous components CAS % HSIS TWA HSIS STEL 3 3 2-methyl pentane 107-83-5 30 - 60 500ppm 1,760mg/m 1,000ppm 3,500/m 3 3 propan-2-ol 67-63-0 30 - 60 400ppm 983mg/m 500ppm 1,230mg/m 3 3 acetone 67-64-1 <30 500ppm 1,185mg/m 1,000ppm 2,375mg/m 3 3 cyclohexane 110-82-7 <10 100ppm 350mg/m 300ppm 1050mg/m 3 n-hexane 110-54-3 <10 20ppm 72mg/m 3 3 carbon dioxide 124-38-9 <10 5,000ppm 9,000mg/m 30,000ppm 54,000mg/m 3. HAZARDS IDENTIFICATION Hazard Classification: Hazardous Material, Dangerous Goods according to the criteria of SafeWork Australia and the ADG-7 code) Risk Phrases: R11 Highly flammable R22 Harmful if swallowed R36/38 Irritating to eyes and skin. R66 - Repeated exposure may cause skin dryness or cracking. R67 Vapours may cause drowsiness and dizziness. R51 - Toxic to aquatic organisms. R52 - Harmful to aquatic organisms. R53 - May cause long-term adverse effects in the aquatic environment. Safety Phrases: S2 - Keep out of reach of children. S9 - Keep container in a well-ventilated place. S16 - Keep away from sources of ignition - No smoking. S20 When using do not eat or drink S21 When using do not smoke S26 - In case of contact with eyes, rinse immediately with plenty of water and seek medical advice. S46 - If swallowed, seek medical advice immediately and show this container or label. S51 Use only in well ventilated areas. S24/25 Avoid contact with skin and eyes. Relevant routes of exposure: Skin, Inhalation, Eyes Potential Health Effects Inhalation: May cause respiratory tract irritation. High concentrations of vapours may cause headache, fatigue, drowsiness and dizziness. Skin contact: May cause allergic skin reaction. May cause skin irritation. Product has a defatting effect on skin. Prolonged contact may cause dryness of skin. Eye contact: Contact with eyes will cause irritation. Ingestion: Harmful. May cause lung damage if swallowed. 4. FIRST AID MEASURES Inhalation: Remove to fresh air. If symptoms develop and persist, get medical attention. Skin contact: Wash with soap and water. Remove contaminated clothing and shoes. Wash clothing before reuse. Get medical attention if symptoms occur. Eye contact: Check for and remove any contact lenses. Immediately flush with copious amounts of water, preferably, lukewarm water for at least 15 minutes, holding eyelids open all the time. Get medical attention. Ingestion: Do not induce vomiting. Rinse mouth thoroughly. Loosen any tight clothing. Keep individual calm. Obtain medical attention. 5. FIRE-FIGHTING MEASURES Material Safety Data Sheet info chemtools.com.au Issued by: Chemtools Pty., Ltd., Page 1 of 4 www.chemtools.com.au Kleanium Circuit Board Cleaner Aerosol Flash point: -17C Cleveland closed cup Autoignition temperature: 300C Flammable/Explosive limits-lower %: 1.2% Flammable/Explosive limits-upper %: 57% Extinguishing media: Foam, dry chemical or carbon dioxide. Special fire fighting procedures: None Unusual fire or explosion hazards: None Hazardous combustion products: Oxides of carbon. Irritating organic vapours. Keep run-off water out of sewers and water sources. Hazchem Code: 2 Y E 6. ACCIDENTAL RELEASE MEASURES Environmental precautions: Extinguish all ignition sources. Ventilate well. Use approved respirator if air contamination is above accepted level. Prevent product from entering drains or open waters. Clean-up methods: Soak up with inert absorbent. Store in a partly filled, closed container until disposal. 7. HANDLING AND STORAGE Handling: Avoid contact with eyes, skin and clothing. Avoid breathing vapour and mist. Wash thoroughly after handling. Storage: For safe storage, store at or below 38C (100F). Keep in a cool, well-ventilated area away from heat, sparks and open flame. Keep container tightly closed until ready for use. Incompatible products: Refer to Section 10. 8. EXPOSURE CONTROLS / PERSONAL PROTECTION Engineering controls: No specific ventilation requirements noted, but forced ventilation may still be required if concentrations exceed occupational exposure limits. Respiratory protection: Use NIOSH approved respirator if there is potential to exceed exposure limit(s). Skin protection: Use impermeable gloves and protective clothing as necessary to prevent skin contact. Neoprene gloves. butyl rubber gloves. Natural rubber gloves. Eye/face protection: Safety goggles or safety glasses with side shields. See Section 2 for exposure limits. 9. PHYSICAL AND CHEMICAL PROPERTIES Physical state: Liquid in Aerosol Canister Colour: Clear, colourless. Odour: Organic solvents. pH: Not available Boiling point/range: 56-82C. Melting point/range: Not available Specific gravity: 0.734 at 20C. Vapour density: >1 Evaporation rate: Not available Solubility in water: Insoluble. 10. STABILITY AND REACTIVITY Stability: Stable. Hazardous polymerization: Will not occur. Hazardous decomposition products: Oxides of carbon. Incompatibility: Strong oxidizers. Strong reducing agents. Conditions to avoid: SeeHandling and Storag (Section 7) andIncompatibilit (Section 10). 11. TOXICOLOGICAL INFORMATION Product toxicity data: 2-methyl pentane Expected to be of low toxicity: LD >2000mg/kg, Rat. Aspiration into lungs when swallowed 50 or vomited may cause chemical pneumonitis which can be fatal. n-hexane Oral: LD 28,710 mg/Kg (rat). Irritation eye: 10 mg mild (rabbit). Investigated as a 50 tumorigen, mutagen and reproductive effector. Carcinogenic effects: None by IARC Isopropyl alcohol Oral: LD 5,045 mg/Kg (rat). Skin: LD 12.8g/Kg (rabbit) Inhalation LC : 16,000ppm/8hr 50 50 50 (rat) Investigated as a tumorigen, mutagen, and reproductive effector. Carcinogenic effects: IARC Category 3 Acetone LD Oral - rat - 5,800 mg/kg Remarks: Behavioural: Altered sleep time (including change in 50 righting reflex). Behavioural: Tremor. LC Inhalation - Rat - 8 h - 50,100 mg/m3 50 Material Safety Data Sheet info chemtools.com.au Issued by: Chemtools Pty., Ltd., Page 2 of 4 www.chemtools.com.au