PFE300-1000 Series 300 to 1008W AC-DC Power Module Features Low pro le, small size 100C baseplate temperature High power density High Ef ciency Suitable for conduction cooling Power Factor Corrected (PFC) Key Market Segments & Applications Speci cations PFE300S PFE700S PFE500F PFE1000F Model PFE500SA AC Input VAC 85 to 265VAC, 47-63Hz (up to 440Hz) (4) Input Current (100 / 220VAC) A 4.0 / 2.0 8.8 / 4.4 6.8 / 3.4 13.6 / 6.6 Model dependant 6.1 / 2.9 Inrush Current (100 /200VAC) (1) A 20 / 40 peak Power Factor - 0.95 minimum, meets EN61000-3-2 Output Voltage Setpoint Accuracy - 2% 1V 2% 2% Ripple and Noise (1) - 1% 4V 1% 1% Over Current Protection % 105 - 140% (Automatic Recovery) 105 - 140% Manual reset Over Voltage Protection - 125 - 145% 60 - 69.6V 125 - 145% 125 - 145% Series Operation - Yes Parallel Operation - No Yes (Droop mode) Yes (Single wire) Yes (Single wire) Power On Signal (ENA) - Open collector (10mA sink current). Low (on) when output is present Auxiliary Supply - None None 10 - 14V, 20mA 10 - 14V, 20mA Remote On/Off (Opto isolated) - None None High = On High = On Overtemperature Protection - Yes Operating Baseplate Temp. C -40 to +100C (2) Storage Temperature C -40 to +100C Humidity (non condensing) - Operating: 20 - 95%RH, Non Operating: 10 - 95%RH Cooling - Conduction Withstand Voltage (1 min) (3) - Input to Output 3kVAC, Input to Baseplate 2.5kVAC, Output to Baseplate 1.5kVDC Isolation Resistance - Output to baseplate: 100M Ohm at 500VDC, 25C ambient, 70%RH 2 Vibration (non operating) - 10-55Hz (1 min sweep), constant amplitude 0.825mm (max 49m/s ), X, Y, Z 1 hour each 2 Shock - 196.1m/s Safety Certi cations - UL60950-1, CSA60950-1 (cUL), EN60950-1, CE mark (LVD) Weight g 250 250 300 500 Size (WxHxL) mm 61 x 12.7 x 116.8mm 70 x 12.7 x 122mm 100 x 13.4 x 160mm in 2.4 x 0.5 x 4.6 2.76 x 0.5 x 4.8 3.94 x 0.53 x 6.3 Warranty yrs 2 years Notes: (Consult Installation Manual for detailed speci cations, test methods and application notes) 1) External components are required, consult Application Notes 2) PFE500S-12, PFE500F-12: -40 to 85C. See instruction manuals for derating curves PFE1000F28 & PFE1000F48: -40 to 85C below 170VAC input voltage. See instruction manuals for derating curves 3) PFE500F, PFE1000F: 500VDC Output to baseplate 4) Reduced PFC above 63Hz. Contact technical support for 440Hz operation. 1-800-526-2324 www.us.tdk-lambda.com/lp/ 85 Disclaimer: us.tdk-lambda.com/lp/legal.htmPFE300-1000 Series Speci cations Output Adjust. Maximum Maximum Load Line Ef ciency Model Voltage (V) Range (V) Current (A) Wattage (W) Reg. (mV) Reg. (mV) typ (4) PFE300S-12 12 9.6 - 14.4 25 300 48 48 81 / 83 PFE500SA-12 12 9.6 - 14.4 33 396 48 48 84 / 86 PFE500F-12 12 9.6 - 14.4 42 504 48 48 81 / 83 PFE1000F-12 12 9.6 - 14.4 60 720 48 48 80 / 82 PFE300S-28 28 22.4 - 33.6 10.8 302 56 56 83 / 85 PFE500SA-28 28 22.4 - 33.6 18 504 56 56 86 / 89 PFE500F-28 28 22.4 - 33.6 18 504 56 56 84 / 86 PFE1000F-28 28 22.4 - 33.6 36 1008 56 56 85 / 87 PFE300S-48 48 38.4 - 57.6 6.3 302 96 96 84 / 86 PFE500SA-48 48 38.4 - 57.6 10.5 504 96 96 88 / 90 PFE500F-48 48 38.4 - 57.6 10.5 504 96 96 84 / 86 PFE1000F-48 48 38.4 - 57.6 21 1008 96 96 84 / 86 PFE700S-48 51 None 14 714 50 - 57V (5) 86 / 89 (4) 100 / 200VAC. Ef ciency values at 115/230VAC are 1% higher. (5) Total regulation range PFE500S & PFE700S Outline Drawing PFE500F Outline Drawing C L See note A See note D See note C AC(N) AC (N) PFE500F-48 -V -V INPUT:100-240VAC 8A 50/60Hz OUTPUT:48V 10.5A AC(L) +V AC (L) +V -S +S -S +S PC TRIM AC-DC EE NN66095095 00 PC TRIM +ON/OFF IOG +ON/OFF IOG BAR CODE -ON/OFF ENA -ON/OFF ENA AUX COM AUX COM R +BC -BC MADE IN JAPAN 3.7 2.54 R +BC -BC See note E 5.26 See note B 15.0 15.0 54.12 111.80.5 122.00.5 Lot No. seal PFE500S Basic connection Heatsink Table Heatsink Size (mm) PFE Module HAF-10L 116.8 x 25.4 x 61 PFE300/500/700S HAF-15L 116.8 x 38.1 x 61 PFE300/500/700S HAF-15T 116.8 x 38.1 x 61 PFE300/500/700S HAL-F12T 122 x 35 x 69.9 PFE500F HAM-F10T 160 x 33.4 x 100 PFE1000F Options Suf x Description Blank M3 tapped mounting inserts (4) /T 3.3mm non-threaded inserts (4) For Additional Information, please visit us.tdk-lambda.com/lp/products/pfe-series.htm 1-800-526-2324 www.us.tdk-lambda.com/lp/ 86 Revision C3: Dec 2013 C L 29.73 5.78 12.0 70.00.5 59.70.5 5.00.5 12.7 2.54 2.54 2.54 9.93 12.0 2.54 5.78