GNT30 MEDICAL SERIES SINGLE OUTPUT POWER SUPPLY
Low Power Medical Power Supplies 30 Watt AC/DC Universal Input Power Supply
SUMMARY
90-264 Vac input range
Overvoltage and short circuit protection
Approved to UL, CSA and EN Standards
Small 50 mm x 80 mm footprint
Class II input available (G2T30)
The GNT30 Series is a 30 W universal input AC/DC Power
supply in a very small footprint. With the medical approvals
the GNT30 is ideal for a variety of medical device applications
including, small single board computers, battery charging, and
running small motors, pumps, and solenoids. The series with full
approval to EN60601-1 Standard improves design-in time, and
reduces end system compliance costs.
O
All specifications are typical at nominal input, full load at 25 C unless otherwise stated
SPECIFICATIONS
OUPUT SPECIFICATIONS INPUT SPECIFICATIONS
Output Power 150 l.f.m. airflow 30 Watts max.(See note 4 Input Voltage range Universal input 100-240 nom (90 - 264 max)
Vac
Total Regulation See table
Input frequency 55 Hz +/- 10 Hz
Turn-on time 1.5 s max.
Input surge current 32 A max.
Transient response 0.25 A/ms 50% load 3.5% max. dev. 1 ms recovery
deviation to 1% Ground Leakage current 132 Vac 60 Hz 100 mA (180 mA single fault)
Temperature Coef- +/-0.03%/oC Input current 120 Vac 0.6 A
ficient
230 Vac 0.37 A
Overvoltage protection 125% +/-10%
Input fuse F1,F2 2.5 A
Short Circuit protection Power cycling Yes
EMC INFORMATION ENVIRONMENTAL SPECIFICATIONS
o
Conducted emissions EN55011 Level B Thermal Performance operating ambient 0-50 C
(see chart)
Radiated emissions EN55011 Level A
o
non-operating -40 to +85 C
Line freq. harmonics EN61000-3-2 Complies
o
0 - 50 C 30 Watts
Voltage fluctuations EN61000-3-3 Complies
150 l.f.m (See note 4.)
ESD Air EN61000-4-2 8 kV contact
o o
50 -70 C ambient derate 2% / C
ESD Contact EN61000-4-2 6 kV air
150 l.f.m
Relative Humidity non-condensing 0% - 95% RH
Radiated immunity EN61000-4-3 3 V/m
Maximum Altitude operating / non-operating 10,000 ft. / 40,000 ft. max.
Fast Transients (EFT) EN61000-4-4 2 kV
Vibration Operating 1.5 g 20-2000 Hz
rms
Line surge immunity EN61000-4-5 1 kV diff /2 kV cm
Non-operating 5 g 20-2000 Hz
rms
Conducted immunity EN61000-4-6 3 V
rms
Shock Operating 20 g 10 ms, half-sine
pk
Power freq. mag. field EN61000-4-8 3 A/m
Non-operating 40 g 10 ms half-sine
pk
Voltage dip immunity EN61000-4-11 5 cycles 40 % vnom 0.5 Watts.
25 cycles 70 % vnom 20 WGENERAL SPECIFICATIONS
Hold-up time 120 Vac, 60 Hz 16 ms at 30 Watts output
Efficiency 120 Vac 30 W output >78 %
isolation voltage input to ouput 4000 Vac
input to ground 1500 Vac
Switching frequency fixed 120 KHz, +/- 5 KHz
Safety Approvals UL/EN/IEC 60601-1 CSA22.2 No.601
UL/EN/IEC 60950-1 CSA22.2 No.60950-1
Maximum weight 100 g (0.22 lbs)
o o o
MODEL NUMBER 40 C Convection 50 C Convection 50 C Airflow RIPPLE REGULATION
GNT30-5 5 V 4.0 A 5 V 3.2 A 5 V 6.0 A 50 mV 2%
GNT30-12 12 V 2.5 A 12 V 1.66 A 12 V 2.5 A 120 mV 2%
GNT30-15 15 V 2.0 A 15 V 1.06 A 15 V 2.0 A 150 mV 2%
GNT30-24 24 V 1.25 A 24 V 0.83 A 24 V 1.25 A 240 mV 2%
GNT30-28 28 V 1.07 A 28 V 0.8 A 28 V 1.07 A 280 mV 2%
GNT30-48 48 V 0.625 A 48 V 0.416 A 48 V 0.625 A 480 mV 2%
NOTES
o o
1. When the input voltage is less than 90 Vac the operating temperature range is 0 C to 40 C. The ripple and regulation
specs. may not be met.
2. Peak output current rating is for 1 minute and 10 % duty cycle.
o
3. Heatsink temperatures should not be allowed to exceed 90 C
4. Output Voltage is adjustable +/- 5% of nominal. See installation instructions (www.condorpower.com)
MECHANICAL NOTES
INPUT J1 AMP P/N 640456-3 TB1
PIN 1 AC LINE PIN 1 AC LINE
PIN 2 N/C PIN 2 AC NEUTRAL
PIN 3 AC NEUTRAL
0.187 Faston GROUND GROUND
OUTPUT J2 AMP P/N 640456-4 TB2
PIN 1 COMMON PIN 1 COMMON
PIN 2 COMMON PIN 2 OUTPUT 1
PIN 3 OUTPUT 1
PIN 4 OUTPUT 1
MATING CONNECTORS CONTACT
INPUT HOUSING 1375820-3 1375819-1
OUTPUT HOUSING 1375820-4 1375819-1
Condor DC Power Supplies Inc. 2311 Statham Parkway, Oxnard CA, 93033, USA. Phone:(805) 486 4565 Fax:(805) 487 8911 Email: condor@condordc.com
GNT30 Rev H 11/11/05.
Data Sheet 2005 Condor DC Power Supplies Inc. The information and specifications contained in this data sheet are believed to be correct at time of publication. However, Condor accepts no
responsibility for consequences arising from reproduction errors or inaccuracies. Specifications are subject to change without notice.