360W Single Output Battery Charger
PB-360 series
Features :
3 stage charging
AC 115/230VAC selected by switch
Built-in passive PFC function compliance to EN61000-3-2 Class A (option)
Protection: Short circuit / Reverse polarity / Over voltage / Over temperature
Charger for lead-acid batteries
2 color LED loading indicator
Low cost, High reliability
FAN on/off control(Depends on charging current)
3 years warranty
(except for 48V) (P type only)
PB 360 P 12
12:14.4V
P:With Passive PFC
24:28.8V
N:Without Passive PFC
48:57.6V
SPECIFICATION
MODEL PB-360 -12 PB-360 -24 PB-360 -48
BOOST CHARGE VOLTAGE 14.4V 28.8V 57.6V
FLOAT CHARGE VOLTAGE 13.6V 27.2V 54.4V
VOLTAGE ADJUSTABLE RANGE 13 ~ 14.7V 26 ~ 28.8V 52 ~ 58.6V
OUTPUT RECOMMENDED BATTERY
80 ~ 240Ah 40 ~ 125Ah 20 ~ 65Ah
CAPACITY(AMP HOURS) Note 5
BATTERY TYPE Open & Sealed Lead Acid
OUTPUT CURRENT (Typ.) Note 6 24.3A 12.5A 6.25A
VOLTAGE RANGE 90 ~ 132VAC / 180 ~ 264VAC selected by switch 127 ~ 187VDC / 254 ~ 370VDC
FREQUENCY RANGE 47 ~ 63Hz
POWER FACTOR (Typ.) >0.65 (with P type) at 230VAC
INPUT EFFICIENCY (Typ.) 85% 86% 87%
AC CURRENT (Typ.) 7A/115VAC 3.5A/230VAC
INRUSH CURRENT (Typ.) COLD START 60A
LEAKAGE CURRENT <3.5mA / 240VAC
SHORT CIRCUIT O/P Built in fuse (FS100) to protect short circuit condition, shut down o/p voltage and can not re-power on
By internal fuse
REVERSE POLARITY
PROTECTION 16 ~ 18V 31 ~ 35V 59 ~ 64V
OVER VOLTAGE
Protection type : Shut down o/p voltage, re-power on to recover
OVER TEMPERATURE Protection type : Automatically derate charge current until zero
FUNCTION Open: Normal work Short: Stop Charging
REMOTE CONTROL (CN5)
WORKING TEMP. -20 ~ +60 (Refer toDerating Curv)
20 ~ 90% RH non-condensing
WORKING HUMIDITY
ENVIRONMENT STORAGE TEMP., HUMIDITY -40 ~ +85 , 10 ~ 95% RH
TEMP. COEFFICIENT
0.05%/ (0 ~ 45
VIBRATION 10 ~ 500Hz, 2G 10min./1cycle, 60min. each along X, Y, Z axes
SAFETY STANDARDS IEC60335-2-29 CB approved by TUV(except for 48V), UL60950-1 approved
WITHSTAND VOLTAGE I/P-O/P:3KVAC I/P-FG:1.5KVAC O/P-FG:0.5KVAC
SAFETY &
ISOLATION RESISTANCE I/P-O/P, I/P-FG, O/P-FG:100M Ohms / 500VDC / 25 / 70% RH
EMC
(Note 4)
EMC EMISSION Compliance to EN55022 (CISPR22) Class B, EN61000-3-2,-3 (only P type)
EMC IMMUNITY Compliance to EN61000-4-2,3,4,5,6,8,11, EN55024, light industry level, criteria A
115.8Khrs min. MIL-HDBK-217F (25 )
MTBF
OTHERS DIMENSION 253*135*48.5mm(L*W*H)
1.5Kg; 6pcs/10Kg/0.95CUFT
PACKING
1. All parameters NOT specially mentioned are measured at 230VAC input, rated load and 25 of ambient temperature.
NOTE
2. Ripple & noise are measured at 20MHz of bandwidth by using a 12" twisted pair-wire terminated with a 0.1uf & 47uf parallel capacitor.
3. Tolerance : includes set up tolerance, line regulation and load regulation.
4. The power supply is considered a component which will be installed into a final equipment. The final equipment must be re-confirmed that it still meets
EMC directives.
5. This is Mean Well's suggested range. Please consult your battery manufacturer for their suggestions about maximum charging current limitation.
6. Maximum charging current will be in the range of 90~110% rated output current.
File Name:PB-360-SPEC 2011-08-17ON/OFF
SWITCH
230
INLET
360W Single Output Battery Charger
PB-360 series
Mechanical Specification
Case No.801A Unit:mm
253
235 12
127 54 48.5
5.5
-V
+V
Air flow
direction
Remote Control(CN5) : JST B2B-XH or equivalent
Assignment Mating Housing Terminal
PIN1,2 Open: Normal work
JST XHP JST SXH-001T-P0.6
or equivalent or equivalent
PIN1,2 Short: Stop Charging
Block Diagram
fosc : 70KHz
FAN ON/OFF
CONTROL
POLARITY
RECTIFIERS RECTIFIERS
POWER REVERSE +V
EMI
I/P & &
PROTECTION
FILTER SWITCHING
PASSIVE P.F.C. FILTER
-V
O.C.P.
FG
DETECTION
CIRCUIT
PWM
O.L.P.
CONTROL
O.V.P.
Output Load VS Temperature
Charging Curve
Start
100
Vboost
90
VFLT
Charge Voltage
80
100%
70
60
10%
Charge Current
Constant Current Constant Voltage
40
stage 1 stage 2 stage 3
30
Red Green
LED COLOR
-20 10 20 30 40 50 60 70
AMBIENT TEMPERATURE ( )
State PB-360-12 PB-360-24 PB-360-48
Vboost 14.4V 28.8V 57.6V
VFLT 13.6V 27.2V 54.4V
File Name:PB-360-SPEC 2011-08-17
LOAD (%)
9.75
LED
9.25
1 2
SVR1 CN5 11
135