TF1500A24K SL Power

TF1500A60K 1500W Single Output 1500W Single Output TF1500 Family TF1500 Family Industrial Grade Industrial Grade FEATURES AND BENEFITS Remote Setting Multiple PSU via RS232, 1500W Fan-Cooled (Load & Temperature RS485 & IC Controlled) Industrial Programmable Output Voltage (0% ~ 105%) Power OK Signal Programmable Output Current (0% ~ 105%) Remote ON/OFF, Remote Sense Function Forced Current Sharing at Parallel Operation Protection: OVP, OLP, OTP, Fan Failure Constant Current Limit 3 Year Warranty Selectable +5V/0.5A or +9V/0.3A Aux Output RoHS Compliant Approved to EN/CSA/IEC/UL62368-1 Global Control via RS232 MODEL SELECTION Output Rated Current Output Ripple & Line Load Voltage 4 Model Number Efficiency 1 3 Volts Current Range Power Noise Regulation Regulation Tolerance TF1500A12K 12V 125A 0-125A 1500W 150mV pk-pk 1% 1% 2% 89% TF1500A15K 15V 100A 0-100A 1500W 150mV pk-pk 1% 1% 2% 90% TF1500A24K 24V 62.5A 0-62.5A 1500W 240mV pk-pk 1% 1% 2% 92% TF1500A48K 48V 31.37A 0-31.3A 1500W 480mV pk-pk 1% 1% 2% 92% 60V 25.0A 0-25A 1500W 600mV pk-pk 1% 1% 2% 93% Notes : 1. See CMD VS Output Curve. 4. Other output voltages available, consult factory. 2. Ripple & noise are measured at 20MHz of bandwidth by using a 12 twisted 5. Recovery after reset AC power ON or inhibit. pair-wire terminated with a 0.1uF & 47uF parallel capacitor. 6. All specifications are typical at 230Vac, full load, at 25C ambient unless noted. 3. Tolerance: includes setup time tolerance, line regulation and load regulation. INPUT OUTPUT Input Voltage and Output Voltage See Model Selection Table on pg 1 100-240Vac, 10%, 47-63Hz, 1127-370Vdc 1 Frequency 1500W continuous See model selection 1 Output Power table for specific voltage model ratings. Input Current 115Vac: 18A, 230Vac: 9A Voltage Range 5.0% Typical adjustment by potentiometer (VR1) Inrush Current 30A/115VAC, 60A/230VAC Voltage Tolerance See Model Selection Table on pg 1 Efficiency See Model Selection Table Hold-Up Time 14ms/230VAC at full load Power Factor 0.95/230VAC, 0.99/115VAC at full load Turn On Time 800ms Leakage Current < 2.5mA/240VAC Rise Time 100ms at full load De-rating may apply in low input voltage. Please check the de-rating Notes : 1. Ripple and Noise See Model Selection Table on pg 1 curve for more details Line/Load Regulation See Model Selection Table on pg 1 Notes : 1. De-rating may apply in low input voltage. Please check the de-rating curve for more details CONNECTOR INFORMATION Input Connector Output Connector Signal Connector Term. 1) AC LINE Pinout: Term. 2) NEUTRAL + and - See Signal Connector Table on pg 3. Term. 3) GROUND Connector: JST PHDR-24VS or equivalent Mating Connector 10 wire lugs 1/4-20 Wire Lugs /terminal: Pins: JST SPHD-002T-P0.5 or equivalent TF1500 Family Datasheet v0920 Copyright 20 20 SL Power Electronics Corp. All rights reserved. Page 1 TF1500 Family Datasheet v0819 Copyright 2019 SL Power Electronics Corp. All rights reserved.1500W Single Output 1500W Single Output 1500W Single Output TF1500 Family TF1500 Family TF1500 Family Industrial Grade Industrial Grade Industrial Grade EMI/EMC COMPLIANCE AUXILIARY SIGNALS Conducted Emissions Certified EN 55022 EN 61204-3 EN 61000-6-3 Selectable +5V/0.5A or +9V/0.3A auxiliary Auxiliary Power output Radiated Emissions Certified EN 55022 EN 61204-3 EN 61000-6-3 Remote ON / OFF Electro-Static Discharge By external switch Control (ESD) Immunity on Power EN55024/IEC61000-4-2 ports Open drain signal low when PSU turns on, Max. Power OK Signal sink current: 20mA, Max. drain voltage: 40V Radiated RF EM Fields EN55022/EN61000-4-3 Susceptibility Adjustment of output voltage is between Output Voltage Trim 0 ~ 105% of rated output Electrical Fast EN55024/IEC61000-4-4 Transients (EFT) /Bursts Adjustment of output current is between Output Current Trim 0 ~ 105% of rated output Surges, Line to Line EN55024/IEC61000-4-5 (Diff Mode) and Line to Please refer to Current Sharing with Remote GND (CMN Mode) 1 Parallel (Current Sharing) Sensing (Parallel Connection) Diagram Conducted Disturbances EN55022/IEC61000-4-6 Notes : 1. In parallel connection only one unit will operate if the total output load is induced by RF Fields less than 5% of the rated power. Rated Power frequency EN55024/IEC1000-4-8 magnetic fields Voltage Interruptions, EN55024/IECEN61000-4-11 PROTECTION Dips, Sags & Surges Harmonic Current EN61000-3-2 120 7% of Vout, Latch Type (Recovery after Emissions Overvoltage Protection reset AC power ON or inhibit). (Refer to VCI vs. OVP Curve) Flicker Test EN61000-3-3 Short Circuit Protection Constant current, auto-recovery Notes : 1. The power supply is considered a component which will be installed into a final equipment. The final equipment must be re-confirmed that it still Overtemperature meets EMC directives. 855C measured on NTC. Auto recovery Protection Overload Protection 105% of rated power, constant current type SAFETY Safety Certifications Approved to EN/CSA/IEC/UL62368-1 ISOLATION SPECIFICATIONS Input-Output: 3000Vac 1 Input-Ground: 1500Vac Isolation Output-Ground: 500Vac RELIABILITY Isolation Resistance I/P-O/P, I/P-FG, O/P-FG: 100M Ohms/500VDC MTBF >112,000 hours per MIL-HDBK-217F Notes : 1. This test is done without enclosure: I/P-O/P 4242VDC. If with enclosure: I/P-O/P 2121VDC,I/P-FG:2121VDC, O/P-FG: 707VDC ENVIRONMENT Operating Temperature -25 ~ +60C (Refer to load derating curve) Temperature Derating See Derating Curve Vibration 10 ~ 500Hz, 2G 10min./1 cycle, period for 60min. each along X, Y, Z axes Compliance to IEC 68-2-6, IEC 68-2-64 Dimensions 127 x 64 x 280mm 5.0 x 2.5 x 11.02 inch Cooling Load and temperature control fan Relative Humidity 20% to 90%, non-condensing Storage Temperature and Humidity -40 ~ +85C, 10 ~ 95% RH Weight & Packing 2.6kg 6pcs/carton, 16.6kg/1.86CUFT TF1500 Family Datasheet v0819 Copyright 2019 SL Power Electronics Corp. All rights reserved. TF1500 Family Datasheet v0920 Copyright 2020 SL Power Electronics Corp. All rights reserved. Page 2 TF1500 Family Datasheet v0819 Copyright 2019 SL Power Electronics Corp. All rights reserved.