25W Class II AC-DC LED Power Supply Features LIGHTLINE 350, 500, 700, 1050mA or 2100mA Output AC/DC-Converter Active Power Factor Correction >0.90 LED DRIVER with 5 year Warranty Efficiency up to 81% IP67 Certified 3 in 1 Dimming Description The 25W LED drivers of the RACD25-A series come with a 3-in-1 dimming function so that the LED load can be dimmed with analog (1-10V), PWM, or resistor inputs. Due to wide input voltage range of 90 - 305VAC these LED drivers are suitable for worldwide use. They operate with efficiencies of up to 81%, feature active 25 Watt PFC PFC, and are fully protected against short circuit, overvoltage, and over-temperature conditions. They are sealed against damp and wet conditions, and the warranty is 5 years. Single Selection Guide Output Part Rated Output Output Efficiency Number Power Current Voltage (typ.) (W) (mA) (VDC) (%) RACD25-350A 20 350 48 - 57 79 RACD25-500A 24 500 36 - 48 81 RACD25-700A 25.2 700 24 - 36 82 RACD25-1050A 25.2 1050 12 - 24 80 RACD25-2100A 25.2 2100 9 - 12 79 RoHS 2011/65/EU Specifications (measured at 240VAC and 25C ambient temperature) 6/6 E340696 Input Voltage Range 90-305 VAC UL8750 Certified Input Frequency Range 47-63Hz EN61347 Certified Power Factor Full Load, 277VAC >0.90 EN55015 Certified Full Load, 230VAC >0.92 EN61547 Certified Full Load, 110VAC >0.98 AC Input Current 110VAC 0.4A 230VAC 0.2A RACD25-A Inrush Current (Max.) 264VAC Cold Start 50A Leakage Current 230VAC <0.25mA Output Current Accuracy (includes Line Regulation, Load Regulation and set-up tolerance) 5% Isolation Voltage 3.75kVAC / 1minute Short Circuit Protection Hiccup mode & recovers after fault condition removed Over Voltage Protection 115% - 135% Output Voltage auto-recovery Derating-Graph Over Temperature Protection Thermistor 105C 10C Type Latch Mode (Ambient Temperature) Dimming Control: PWM 1<Adj<10V(500Hz - 3kHz) Analogue control by external voltage 1-10VDC A Resistance 10K - 100K . A Set Up Time Full Load, 120VAC 2 sec - A Vibration 10-500Hz, 2G, 60 Min. along X, Y and Z ) 2 0 3+2 Storage Humidity 10% - 95% RH , A Operating Humidity 20% - 95% RH Non-Condensing A Weight 384g Dimension (LxBxH) 110 x 73.5 x 33mm 0 + Operating Temperature Range Full load -20C to +50C ) (free air convection 10LFM) Case Temperature 85C 10C Note: Storage Temperature -40C to +80C All LED Drivers may not be used without a IP Rating IP67 load. They must be switched on the primary side only. Noncompliance may damage the Isolation Resistance 500VDC 100M LED or reduce its lifetime. MTBF (+25C) using MIL-HDBK 217F 200 x 10 hours Refer to Application Notes continued on next page L-38 REV: 0/2015 www.recom-power.comRACD25-A 4 ( RACD25-A LIGHTLINE AC/DC-Converter Series Specifications (measured at 240VAC and 25C ambient temperature) Certifications: UL Standards Report: E340696 UL8750 (based on) UL1310 Safety Standards Report: P201403013 EN61347-1 EN61347-2-13 Emission Report: HA130831-SACE EN55015, Class B IEC61000-3-2 IEC61000-3-3 FCC Report: HA130831-SAFD Part 15, Class B EMC Report: HA130831-SACE IEC61000-4-2, 3, 4, 5, 6, 8, 11 Immunity EN61547 IP67 Report: 14022002 IEC/EN 60598-1 IEC/EN 60529 Technical Characteristic Maximum Number of LED drivers per circuit breakers Condition Circuit Breaker Circuit Breaker Current Load vs. Input Voltage Dimming Curve B + Typ 10A 16A 20A 25A A 115VAC, 1Ohm . A C 32 48 57 72 90 phase angle - A , A B 24 38 46 58 A 230VAC, 1Ohm 90 phase angle C 38 62 74 92 3 + * . , 3+ 2 2 ) E E 7 8 2 2) - A A - B 28 44 53 66 277VAC, 1Ohm 90 phase angle C 44 71 84 106 Package Style & Pinning / ( 3K < <H A 1 A 2 I1 <H 6 4 9 A D 5 6 A 5 <= J J ( ( The product information and specifications are subject to change without prior notice. RECOM products are not authorized for use in safety-critical applications (such as life support) without RECOMs explicit written consent. A safety-critical application is defined as an application where a failure of a RECOM product may reasonably be expected to endanger or cause loss of life, inflict bodily harm or damage property. The buyer shall indemnify and hold harmless RECOM, its affiliated companies and its representatives against any damage claims in connection with the unauthorized use of RECOM products in such safety-critical applications. www.recom-power.com REV: 0/2015 L-39 ( ( ( / ( (