GNT60 MEDICAL SERIES
SINGLE OUTPUT POWER SUPPLY
Low Power Medical Power Supplies 65 Watt AC/DC Universal Input Power Supply
Summary:
100 - 240 Vac nominal input range
Overvoltage and short circuit protection
D C P o w e r S u p p l i e s
Approved to UL, CSA and EN Standards
Class II input available (G2T60)
RoHS Compliant Model Available (G suffix)
The GNT60 Series is a 65 W universal input AC/DC power
supply in a very small footprint. With the medical approvals
the GNT60 is ideal for a variety of medical device applications
including small single board computers, battery charging,
running small motors, pumps, and solenoids. The series, with
approval to 60601-1 and 60950 standards, improves design-in
time and reduces end system compliance costs.
Specifications:
OUPUT SPECIFICATIONS INPUT SPECIFICATIONS
Output Power Natural Convec- 60 Watts max.(65 W with airflow) Input Voltage range Universal input 100-240 nom (85 - 264 max) Vac
tion See table
Input frequency 55 Hz +/- 10 Hz
Total Regulation See table
Input surge current Thermistor 37 A max.
limited
Rise time At turn-on 2.0 s max.
Ground Leakage 264 Vac 60 Hz 300 A max. (400 A single fault)
Transient response Main output 50% 3.55% max. dev. 1 s recovery
current
0.2 A/s to 0.5%
Input current 120 Vac 1.2 A
Temperature +/-0.03%/oC
Coefficient
230 Vac 0.7 A
Overvoltage 108% to 130%
Input fuse F1,F2 3.15 A
protection
Short Circuit Cycling/foldback Yes
protection
EMC INFORMATION ENVIRONMENTAL SPECIFICATIONS
o
Conducted emissions EN55011 Level B Thermal Performance operating ambient 0-70 C
(see ratings chart)
Radiated emissions EN55011 Level A
o
non-operating -40 to +85 C
Line freq. harmonics EN61000-3-2 Complies
o
0 - 50 C Full load. See table.
Voltage fluctuations EN61000-3-3 Complies
ESD Air EN61000-4-2 8 kV contact
o
50 -70 C ambient derate to 50%
ESD Contact EN61000-4-2 6 kV air
Relative Humidity non-condensing 5% - 95% RH
Radiated immunity EN61000-4-3 3 V/m
Maximum Altitude operating / non-operating 10,000 ft. / 40,000 ft. max.
Fast Transients (EFT) EN61000-4-4 2 kV
Vibration 5 Hz- 500 Hz 2.5 g rms
Line surge immunity EN61000-4-5 1 kV diff /2 kV cm
Shock per MIL-STD-810E 516.4 part IV
Conducted immunity EN61000-4-6 3 Vrms
Power freq. mag. field EN61000-4-8 3 A/m
Voltage dip immunity EN61000-4-11 5 cycles 40 % Vnom 22% load
100 Vac 25 cycles 70 % Vnom 52% load
0.5 cycles <5% Vnom 88% load
O
All specifications are typical at nominal input, full load at 25 C unless otherwise statedGENERAL SPECIFICATIONS
Hold-up time 120 Vac, 60 Hz 16 ms at 60 Watts output
Efficiency 120 Vac 60 W output >80 %
Isolation voltage input to ouput 4000 Vac
input to ground 1500 Vac
Switching frequency fixed 60 KHz, +/- 5 KHz
Safety Approvals UL/EN/IEC 60601-1 CSA22.2 No.601,
UL/EN/IEC 60950-1 1st Edition, CSA22.2 No.60950-1-03
Maximum weight 140 g (0.29 lbs)
o o o
MODEL NUMBER 50 C Airflow 65 W (1) 40 C Convection 50 C Convection RIPPLE REGULATION
GNT60-12 12 V 5.0 A 12 V 4.2 A 12 V 3.35 A 120 mV 2%
GNT60-15 15 V 4.35 A 15 V 4.0 A 15 V 3.7 A 150 mV 2%
GNT60-24 24 V 2.7 A 24 V 2.1 A 24 V 1.9 A 240 mV 2%
GNT60-48 48 V @ 1.35 A 48 V @ 1.25 A 48 V @ 1.35 A 480 mV 2%
NOTES
1. All models 65 W with 100 lfm airflow except GNT60-12 (60 W)
o o
2. When the input voltage is less than 90 Vac the operating temperature range is 0 C to 40 C. The ripple and regulation specs. may not be met.
3. Peak output rating is 70 Watts for 1 minute.
4. Noise 0.5% RMS, 1% Pk-Pk, 20 MHz Bandwidth, differential mode. Measured with scope probe directly across output terminals of the power supply.
o
5. Heatsink temperatures should not be allowed to exceed 90 C
6. Installation data is online at www.condorpower.com
7. Add G suffix to model number for RoHS compliant model.
o
8. Convection cooling rating is 40 Watts worst case (GNT60-12 @ 50 C)
Mechanical Notes
INPUT J1 AMP P/N 640445-2
PIN 1 AC LINE
PIN 3 AC NEUTRAL
GROUND 0.187 FASTON
OUTPUT J2 AMP P/N 640445-4
PIN 1 OUTPUT 1
PIN 2 OUTPUT 1
PIN 3 COMMON
PIN 4 COMMON
MATING CONNECTOR (TYCO/AMP)
INPUT HOUSING 640250-3 CONTACT 640706-1
OUTPUT HOUSING 640250-4 CONTACT 640706-1
SL Power Electronics Corp., 6050 King Drive, Bldg. A, Ventura, CA 93003, USA. Phone:(805) 486 4565 Fax:(805) 487 8911 www.slpower.com. GNT60 Rev 4/7/10.
Data Sheet 2010 Condor DC Power Supplies Inc. The information and specifications contained in this data sheet are believed to be correct at time of publication.
However, SL Power accepts no responsibility for consequences arising from reproduction errors or inaccuracies. Specifications are subject to change without notice.